Toyota
Jeep Cherokee
 Service Manual
Transmission and transfer case » Automatic transmission-30RH » Adjustments
Valve body

CONTROL PRESSURE ADJUSTMENTS

There are two control pressure adjustments on the valve body;

  •  Line Pressure
  •  Throttle Pressure

Line and throttle pressures are interdependent because each affects shift quality and timing. As a result, both adjustments must be performed properly and in the correct sequence. Adjust line pressure first and throttle pressure last.

LINE PRESSURE ADJUSTMENT

Measure distance from the valve body to the inner edge of the adjusting screw with an accurate steel scale (Fig. 234).

Distance should be 33.4 mm (1-5/16 in.).

Fig. 233 Rear Band Adjustment Screw Location
Fig. 233 Rear Band Adjustment Screw Location

1 - 30RH REAR BAND LEVER AND ADJUSTING SCREW
2 - 32RH REAR BAND LEVER AND ADJUSTING SCREW

If adjustment is required, turn the adjusting screw in, or out, to obtain required distance setting.

NOTE: The 33.4 mm (1-5/16 in.) setting is an approximate setting. Manufacturing tolerances may make it necessary to vary from this dimension to obtain desired pressure.

One complete turn of the adjusting screw changes line pressure approximately 1-2/3 psi (9 kPa).

Turning the adjusting screw counterclockwise increases pressure while turning the screw clockwise decreases pressure.

THROTTLE PRESSURE ADJUSTMENT

Insert Gauge Tool C-3763 between the throttle lever cam and the kickdown valve stem (Fig. 235).

Push the gauge tool inward to compress the kickdown valve against the spring and bottom the throttle valve.

Maintain pressure against kickdown valve spring.

Turn throttle lever stop screw until the screw head touches throttle lever tang and the throttle lever cam touches gauge tool.

Fig. 234 Line Pressure Adjustment
Fig. 234 Line Pressure Adjustment

1 - WRENCH
2 - 1-5/16 INCH

NOTE: The kickdown valve spring must be fully compressed and the kickdown valve completely bottomed to obtain correct adjustment.

    More about «Adjustments»:

    Gearshift cable

    Brake transmission shift interlock cable adjustment

    Transmission throttle valve cable adjustment

    Front band adjustment

    Rear band adjustment

    Valve body

    Jeep Cherokee Service Manual / Transmission and transfer case / Automatic transmission-30RH / Adjustments / Valve body

    Jeep Cherokee Service Manual

    Categories


    © 2017-2022 Copyright www.jcherokee.com